gti 8v hesitation at low rpm
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
gti 8v hesitation at low rpm
although running well and the idling probs now sorted, there is still a little hesitation between 1500-2500rpm, def not a misfire, if it's foot to floor it feels fine but under gentle acceleration its there, timing has been set with a strobe according to manufacture settings (and the vacuum advance seems to be working ok) new coil, plugs, leads, diz cap and arm, fuel pump good, fuel pressure reg checked and ok, new fuel lines, dosen't seem to make any difference whether the engine is hot or cold, it dosen't stall and starts ok even when hot. have tried advancing/retarding timing a few degrees but makes no difference, feels like a low speed fuel starvation prob but not sure, any ideas?
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
Dirty injectors?
Dave.
2004 C5 Exclusive Estate 2.2hdi automatic.
1990 Bx TGS automatic.
2004 C5 Exclusive Estate 2.2hdi automatic.
1990 Bx TGS automatic.
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
Yeah could be will run some injector cleaner through it.
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
That stuff causes more problems long term than it solves!rutter123 wrote:Yeah could be will run some injector cleaner through it.
Best to remove them and get them cleaned by an operation with an ASNU ultrasonic machine and serviced with new filters, 'o' rings and pintle caps. It'll feel like a new car.
1991 BX19GTi Auto
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
So ii have read today they cause more harm than good and a waste of money, money better spent having them pro cleaned, a local fuel inj specialist said they can do them for £17 each but didnt mention the caps or orings?
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
£17 each is about what is cost me in the past but of course it's worth asking the question whether that does include the new filters, pintle caps and O rings. (It should do.)
If you get the opportunity of viewing the servicing take it, it's especially interesting to view the differences and uniformity of fuel metering tests both before and after the servicing.
If you get the opportunity of viewing the servicing take it, it's especially interesting to view the differences and uniformity of fuel metering tests both before and after the servicing.
1991 BX19GTi Auto
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
Yes have seen on youtube the before/after results, but i'm still not convinced the injectors are causing the prob, i think this is more airflow related? Is it possible to physically see if they are dirty or is it more internal than that?
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
It is internal, so no really external evidence. The pintle caps may show signs of external carbonation, but it's more the internal crud that needs to be ultrasonically completely cleaned out because of its affect on the various spray patterns, their efficiency and delivery.
1991 BX19GTi Auto
- Jaba
- 1K Away
- Posts: 1897
- Joined: Tue Jul 05, 2005 7:54 am
- Location: Usually in the garage
- My Cars: BX GTi, C3 Auto
- x 82
Re: gti 8v hesitation at low rpm
My GTi has always had a tendency to do this, but only when hot. I have had the injectors cleaned and cleaned all h2o from the fuel tank to no avail.
What does improve it is to tweak the co reading above the legal limit. Keeping it lower just at MOT time.
Another throttle housing might reveal the source in your case though - just guessing BTW.
What does improve it is to tweak the co reading above the legal limit. Keeping it lower just at MOT time.
Another throttle housing might reveal the source in your case though - just guessing BTW.
The Joy of BX with just one Citroën BX to my name now. Will I sing Bye Bye to my GTI or will it be Till death us do part.
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
I will give the CO adjuster a few turns back in as it was wound out 3 1/2 turns to bring the emissions down for the MOT, have checked the plugs today, which were very white so i guess its running a little lean.
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
Could it be a dirty air mass meter?
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
air mass meter or airflow meter? same thing-do you mean the sealed part on top of the airbox? ive read somewhere that cleaning the tracks in here can cure? how to clean and what with? running out of options. just as a matter of course today i changed all the newly fitted bits i.e plugs,leads, diz cap and r arm,tps, coil, and fitted all the old ones back on, it made no difference wotsoever, the flat spot is still there in the same place. too lean? will richen the mixture setting a few turns and go from there.adamskibx wrote:Could it be a dirty air mass meter?
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
Richened the mixture up back to its pre MOT position, made no difference, still hesitating, next step airflow meter track clean.
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
Re: gti 8v hesitation at low rpm
It must be worth getting your injectors serviced before trying this work? If the spay patterns are defective or weak then mixture adjustments will have no great influence and interfering with the tracks on the airflowmeter if unneccessary risks permanent damage.rutter123 wrote:Richened the mixture up back to its pre MOT position, made no difference, still hesitating, next step airflow meter track clean.
If Injector servicing doesn't cure it, at least you are starting from a known good position.
1991 BX19GTi Auto
-
- Over 2k
- Posts: 2695
- Joined: Sun Sep 02, 2012 9:54 pm
- Location: South Lincs
- My Cars: 90 Bx Tzd turbo ven red 295k
74 D Super 5 black
05 Volvo V50 2.0d 180k
65 Peugeot Boxer work van 280k - x 137
Re: gti 8v hesitation at low rpm
Point taken, unknown territory there, injectors being cleaned at boxer motor works in Ashford next week £80 full clean and refurb.
90 BX Tzd turbo 294k SORN undergoing major surgery
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability
90 BX Tzd turbo estate 46k awaiting surgery
65 Peugeot Boxer Van the new workhorse
52 Toyota Rav4 180k Bulletproof Jap reliability