Timex and friends

Tell us about life with your BX, or indeed life in general!
Post Reply
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

With the rot and bodges cut out it the hole just gets bigger and bigger
Image

New metal welded into the trailing edge of the inner wing and the boot floor
Image

Lower corner closed off with new metal
Image

Same repair from the other side - I got the rear edge slightly wrong as I didn't have much to go on, but luckily had enough metal there to reshape it.
Image

A new bumper mounting plate welded in - slightly smaller than the original but also slightly thicker
Image

Towing eye welded in - it was originally on the other side of this panel, but this was easier
Image

With all the rust cut out of this end of the back panel, this small repair was needed to the inner structure
Image

Again made up the new metal piecemeal, this time so that I didn't scrap too much if I got it wrong
Image

Image

For some reason I don't have the completed back panel repair to hand, so I'll take that pic again when I next go down there

Bumper end mount made and fitted
Image
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

New bump stop made up and painted
Image

Bump stop fitted
Image

I decided to remove the fuel tank mount as it was holed and rusty
Image

This is the hole it left
Image

Mount with rust removed and a new section welded in
Image

Repairs made to the boot floor and inner wing before the tank mount could be refitted
Image

Image

Image

Tank mount back in place, fitted by a mix of plug and seam welding
Image
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

I bet you can't guess what I did on my days off last week - Welding the Visa!

This is the front RH corner of the boot floor from underneath:

Image

With the rust cut outI started putting it all back together again

Image

This is the reinforcing angle repaired

Image

Then the boot floor and kick plate repairs were welded in

Image

As I seemed to miss it last last time, here's the completed rear corner

Image

Excuse the poor quality of the next few pics (what I thought was poor screen was a dirty lens :oops: [-X ), but this was typical of the wing inner skin.

Image

The rot was again cut out, the inner surfaces of the wing and repair sections painted, then the whole lot welded up

Image

Luckily all the outer wing skin needed was a piece of joining flange replacing and this small repair that's hidden under the plastic trim

Image

With a clean camera lens, I then started on the back panel under the tailgate aperture

Image

One of the repair sections I made

Image

And the same section welded in

Image

A wire wheel across the bottom of the panel revealed more rust, which was cut away to reveal a rearedge of the boot floor that wasn't much better

Image

Everything trimmed back ready for new metal

Image

And it all welded back up again

Image
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

Some of you may have read elsewhere that Timex started acting it's age and miles as well as showing it while in Ireland. Currently there's a seemingly ever growing list of electrical issues that have gone from annoying to illegal and potentially dangerous. I have also looked around the bodywork and the windscreen pillars both need surgery at their bases, and the roof on the driver's side finally lost the ally tape that I think Ian applied, displayig some major rust up there. The rear sub frame mounts are in a bad way, and the sills will almost certainly need work for the next MOT (I'm amazed they didn't for the last one!). The driver's seat is also becoming increasingly uncomfortable - omething really brought home to me when riding in Chris's car in Ireland. This all tells me one thing - it's restoration time!

Thanks to all those who have either sold or given me parts over the last couple of years, along with a few finds of my own, I have new bumpers and front wings, plus good (or at least repairable) 2nd hand bonnet, doors, tailgate and passenger rear wing - All I need for the exterior is a pair of sills, which I hope to be able to locate through the local panel specialist - watch this space! As for the interior I have a steering wheel and main dash assembly to go in, plus a set of carpets, but I'm still looking for a few bits, such as the interior trim for the passenger mirror, and either some seats or seat covers. I did wonder about robbing Fred's interior as that particular car's being modified anyway, but I don't think it'll be good enough for what I want. Any ideas greatfully recieved!

This isn't happening immediately, as I want to get Visal Diesel done first, but hopefully work will start in September. Fred's slipping down the queue butwill have the benefit of going back under cover as a result!

In the meantime, for those who don't know, I've done something very silly (again!)

Image

It's a 1992 XM Turbo SD, which for those who don't know is the mid range 2.1 TD, in this case with manual gearbox - unusually for me it has more than a few weeks MOT on it and it runs! mileage is just a few thousand less then Timex, but unlike Timex it has a very full history file with a scary amount of work done over the years. Work so far has been restricted to painting the bonnet (which still needs work), cleaning and polishing it and trying to keep everything working on the damn thing! It's a great drive but I suspect it'll be a love/hate relationship while it drives me to distraction as apparently only a Mk1 XM can! her it is looking slightly shinier:

Image

Image
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
Tinkley
1K Away
Posts: 1502
Joined: Sat Jun 06, 2009 11:27 am
Location: N Hants England
x 8

Re: Timex and friends

Post by Tinkley »

I'm pretty sure Chevronics have some BX sills, if you cannot find any Mike. New ones at about 45 quid and at least you can be fairly sure they will be a 'good fit' as I'm sure they will not accept poor quality parts.
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

I'm thinking of popping over to Chevronics anyway in the near future, as I want a couple of spray bars, some octopi and (if they have any left) some XM bumper trims. Sills may be another to add to the list of wants!
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
Dollywobbler
Over 2k
Posts: 3940
Joined: Sun Dec 04, 2005 2:25 pm
Location: Wales
Contact:

Re: Timex and friends

Post by Dollywobbler »

I have a nearside sill Mike. Not much use to me and I could do with the money! £30 to you sound ok?
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

That sounds good Ian, just have to come ad get it!
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
Dollywobbler
Over 2k
Posts: 3940
Joined: Sun Dec 04, 2005 2:25 pm
Location: Wales
Contact:

Re: Timex and friends

Post by Dollywobbler »

I'll let you know when I'm over your way. Bound to be at some point. If you need it sooner, you're very welcome to pop in for a brew. It's only about a 3 hour journey!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

Thanks Ian, I'll le you know if it becomes urgent, although somehow I suspect that I'll have plenty to keep me occupied!
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

As I don't have enough rusty projects in my life, I went and added another one to the collection this week:

Image

Some will havealready seen this mentioned, but it's a late Mk1 AX GT, with air con and no sun roof. I was told that it was built for Australia but ended up here instead, but research into the badging (badged as a GT Japon on the tailgate) has suggested that it may have actually been originally destined for Japan - more research needed methinks!!!

If I get a chance tomorrow I have lots of rusty Visa pics to add. I've also been asked to write something for the Visa column in the Citroenian as it seems that not many people bother to rescue a car this bad (now where have I heard that before???)
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
Tim Leech
Over 2k
Posts: 15565
Joined: Tue Apr 15, 2008 11:12 am
Location: Derbyshire
My Cars: Various
x 141

Re: Timex and friends

Post by Tim Leech »

Aircon on a AX! never heard of that, well saved Mike!
Lots of Motors, mostly semi broken....
mds141
Over 2k
Posts: 5288
Joined: Sat Jul 31, 2010 1:26 am
Location: Lancaster
x 9

Re: Timex and friends

Post by mds141 »

You're a legend Mike. :-)
Mark Smith

Is it just me or is everything shit?

1989 BX GTi 16 valve. Blanc Alpine. Completed the Citroen Classic Challenge Ecosse and 1337 miles without a hitch.
2000 XM VSX 2.1 td Auto. Rouge Magenta.
TGD saloon many years ago.

1990 Swift 'Corniche' 12/2 aka BXClub HQ.
Honda Firestorm. Gone, but not forgotten.
2015 Triumph Tiger Explorer XC.
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

I don't think air con was ever officially offered in the UK, only for hotter climates. It certainly makes things look cramped underthe bonnet - the Aircon exchanger is in front of the rad and about the same size, wheile the compressor runs off the auxiliary belt that drives the alternator. Under the dash below the standard heater controls there's an additional pod sat on top of the tunnel with a couple of rotary controls for temp. and fan, and 3 vent outlets that can be adjusted for direction. Haven't delved into whether it's plumbed into any of the other vents yet.
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
User avatar
citsncycles
Over 2k
Posts: 3224
Joined: Sun Aug 08, 2010 9:14 pm
Location: Dursley, Gloucestershire

Re: Timex and friends

Post by citsncycles »

Took Timex out for the first time in a few weeks today, up to Gloucester to collect some paint for the XM, then to Tony Weston's place to collect some Visa bits - it's now loaded to the roof with the mortal remains of a C reg 10E. It was good to be behind the wheel again, much smoother ride than the XM, although the on/off brakes and the relatively low power took a few miles to adjust to again. After the XM it did bring home how bad the driver's seat is though, and it's leaking from the pressure regulator.
Mike Sims
BX 19RD Estate Mk1 - Timex!
BX 4X4 Estate - Oh god, I've done it again!
BX 17RD MK1 - it called to me!
BX14 TGE, - SOLD
XM Turbo SD,GS Club Estate,Visa 17D Leader,HY Pickup,Dyane Nomad,Dyane 6,2CV AZL,Falcon S,Trabant P50,3x Land Rovers (88" series 1,109" series 2a FFR,series 2a Marshall ambulance),DKW F7, Lambretta LD150 x 1.5,Mobylette SP93,Ural Cossack,Ural M63,CZ 250 Sport,Honda Varadero 125,lots of bicycles & tricycles including (but not only) Sunbeams,Higgins & Bates!
Post Reply